Deep-water regions often have winds favorable for offshore wind turbines, and floating turbines currently show the greatest potential to exploit such winds. This work established proper scaling laws for model tests, which were then implemented in the construction of a model wind turbine with optimally designed blades. The aerodynamic,hydrodynamic, and elastic characteristics of the proposed new multi-column tension-leg-type floating wind turbine(Wind Star TLP system) were explored in the wave tank testing of a 1:50 scale model at the State Key Laboratory of Ocean Engineering at Shanghai Jiao Tong University. Tests were conducted under conditions of still water, white noise waves, irregular waves, and combined wind, wave, and current loads. The results established the natural periods of the motion, damping, motion response amplitude operators, and tendon tensions of the Wind Star TLP system under different environmental conditions, and thus could serve as a reference for further research.
以UAE phase VI和MEXICO(model experiment in controlled conditions)项目以及中国空气动力研究与发展中心(China aerodynamics research and development center,CARDC)相关的研究工作为背景,概述了近年来风力机流场测量、压力分布测量、测力等风洞试验技术的进展,介绍了在风洞的影响、叶素的等效远场自由来流条件确定、三维旋转效应、动态入流效应、流场结构和诱导效应方面的重要研究成果.文章还简介了CARDC的大型风力机风洞试验研究工作及一些思路.
In order to investigate the aerodynamic characteristics of 6-MW wind turbine, experimental study on the aerodynamic characteristics of the model rotor system and on characterization of a wind generation system is carried out. In the test, a thrust-matched rotor system and a geometry-matched rotor system, which utilize redesigned thrustmatched and original geometry-matched blades, respectively, are applied. The 6-MW wind turbine system is introduced briefly. The proper scaling laws for model tests are established in the paper, which are then implemented in the construction of a model wind turbine with optimally designed blades. And the parameters of the model are provided. The aerodynamic characteristics of the proposed 6-MW wind rotor system are explored by testing a 1:65.3 scale model at the State Key Laboratory of Ocean Engineering at Shanghai Jiao Tong University. Before carrying out the wind rotor system test, the turbulence intensity and spatial uniformity of the wind generation system are tested and results demonstrate that the characterization of the wind generation system is satisfied and the average turbulence intensity of less than 10% within the wind rotor plane is proved in the test. And then, the aerodynamic characteristics of 6-MW wind rotor system are investigated. The response characteristic differences between the thrust-matched rotor system and the geometry-matched rotor system are presented. Results indicate that the aerodynamic characteristics of 6-MW wind rotor with the thrust-matched rotor system are satisfied. The conclusion is that the thrust-matched rotor system can better reflect the characteristics of the prototype wind turbine. A set of model test method is proposed in the work and preparations for further model basin test of the 6-MW SPAR-type floating offshore wind turbine system are made.
MENG LongHE Yan-pingZHAO Yong-shengPENG TaoYANG Jie
This paper presents a coupled dynamic response analysis of a multi-column tension-leg-type floating wind turbine(Wind Star TLP system) under normal operation and parked conditions. Wind-only load cases, wave-only load cases and combined wind and wave load cases were analyzed separately for the Wind Star TLP system to identify the dominant excitation loads. Comparisons between an NREL offshore 5-MW baseline wind turbine installed on land and the Wind Star TLP system were performed. Statistics of selected response variables in specified design load cases(DLCs) were obtained and analyzed. It is found that the proposed Wind Star TLP system has small dynamic responses to environmental loads and it thus has almost the same mean generator power output under operating conditions as the land-based system. The tension mooring system has a sufficient safety factor, and the minimum tendon tension is always positive in all selected DLCs. The ratio of ultimate load of the tower base fore-aft bending moment for the Wind Star TLP system versus the land-based system can be as high as 1.9 in all of the DLCs considered. These results will help elucidate the dynamic characteristics of the proposed Wind Star TLP system, identify the difference in load effect between it and land-based systems, and thus make relevant modifications to the initial design for the Wind Star TLP system.
Tower,Spar platform and mooring system are designed in the project based on a given 6-MW wind turbine.Under wind-induced only,wave-induced only and combined wind and wave induced loads,dynamic response is analyzed for a 6-MW Spar-type floating offshore wind turbine(FOWT) under operating conditions and parked conditions respectively.Comparison with a platform-fixed system(land-based system) of a 6-MW wind turbine is carried out as well.Results demonstrate that the maximal out-of-plane deflection of the blade of a Spar-type system is 3.1% larger than that of a land-based system;the maximum response value of the nacelle acceleration is 215% larger for all the designed load cases being considered;the ultimate tower base fore-aft bending moment of the Spar-type system is92% larger than that of the land-based system in all of the Design Load Cases(DLCs) being considered;the fluctuations of the mooring tension is mainly wave-induced,and the safety factor of the mooring tension is adequate for the 6-MW FOWT.The results can provide relevant modifications to the initial design for the Spar-type system,the detailed design and model basin test of the 6-MW Spar-type system.
